Combustion and Emission Characteristics of Biodiesel from Vegetable Oils in the Diesel Engine: A Review

Author(s): Kianoosh Shojae, Majid Mahdavian*

Journal Name: Current Biochemical Engineering

Volume 6 , Issue 2 , 2020

Become EABM
Become Reviewer
Call for Editor

Graphical Abstract:


Background: Vegetable oil of Fatty Acid Methyl Esters (FAME) that is obtained by triglycerides of transesterification in the presence of methanol, recently, has been highly regarded by scholars for use in diesel engines. These oils can be used as biodiesels in diesel engines and have various benefits (these fuels are renewable, biodegradable, and nontoxic).

Objective: In this work, many studies are reviewed in the field of using vegetable oils as biodiesel in diesel engines. Moreover, a simulation study is conducted to compare oxygen and peak pressure of a diesel engine fueled by three different biodiesels in comparison to diesel fuel. We have examined the chemical ignition delay time and kinetic viscosity of biodiesel in the combustion process of diesel engine and the effects of these factors are evaluated on air–fuel mixing and subsequent combustion.

Keywords: FAME, peak pressure, vegetable oil, diesel engine, biodiesel, review.

K. Shojae, and M. Mahdavian, "Environmental effects of using Methanol as a biofuel into the combustion chamber of a heavy-duty diesel engine", Adv. Environ. Technol., vol. 2, no. 1, pp. 1-10, 2016.
K. Shojae, and M. Mahdavian, "Influences of spray angle and bowl center depth on power and exhaust emissions in a dual fuel direct injection engine", Int. J. Engine Res., vol. 19, no. 6, pp. 643-652, 2017.
K. Shojae, and M. Mahdavian, "Modification of piston bowl geometry and injection strategy, and investigation of EGR composition for a DME-burning direct injection engine", Adv. Environ. Technol., vol. 3, no. 1, pp. 1-10, 2017.
M. Kaieda, T. Samukawa, T. Matsumoto, K. Ban, A. Kondo, Y. Shimada, H. Noda, F. Nomoto, K. Ohtsuka, E. Izumoto, and H. Fukuda, "Biodiesel fuel production from plant oil catalyzed by Rhizopus oryzae lipase in a water-containing system without an organic solvent", J. Biosci. Bioeng., vol. 88, no. 6, pp. 627-631, 1999.
[] [PMID: 16232675]
K.V. Krishna, G.R.K. Sastry, M.V.S.M. Krishna, and J.D. Barma, "Investigation on performance and emission characteristics of EGR coupled semi adiabatic diesel engine fuelled by DEE blended rubber seed biodiesel", Eng. Sci. Technol. Int. J., vol. 21, no. 1, pp. 122-129, 2018.
M. Feroskhan, S. Ismail, M.G. Reddy, and A.S. Teja, "Effects of charge preheating on the performance of a biogas-diesel dual fuel CI engine", Eng. Sci. Technol. Int. J., vol. 21, no. 3, pp. 330-337, 2018.
H. Sivasubramanian, Y.K. Pochareddy, G. Dhamodaran, and G.S. Esakkimuthu, "Performance, emission and combustion characteristics of a branched higher mass, C3 alcohol (isopropanol) blends fuelled medium duty MPFI SI engine", Eng. Sci. Technol. Int. J., vol. 20, no. 2, pp. 528-535, 2017.
N. Acharya, P. Nanda, S. Panda, and S. Acharya, "Analysis of properties and estimation of optimum blending ratio of blended mahua biodiesel", Eng. Sci. Technol. Int. J., vol. 20 2017, pp. 511-517, .
J. Milano, H.C. Ong, H.H. Masjuki, A.S. Silitonga, W.H. Chen, F. Kusumo, S. Dharma, and A.H. Sebayang, "Optimization of biodiesel production by microwave irradiation-assisted transesterification for waste cooking oil-Calophyllum inophyllum oil via response surface methodology", Energy Convers. Manage., vol. 158, pp. 400-415, 2018.
S.A. Basha, K.R. Gopal, and S. Jebaraj, "A review on biodiesel production, combustion, emissions and performance", Renew. Sustain. Energy Rev., vol. 13, no. 6, pp. 1628-1634, 2009.
M. Koncar, M. Mittelbach, and R. Marr, "A Low-Waste Process for the Production of Biodiesel AU - Ahn, E", Sep. Sci. Technol., vol. 30, no. 7-9, pp. 2021-2033, 1995.
E. Alptekin, M. Canakci, and H. Sanli, "Biodiesel production from vegetable oil and waste animal fats in a pilot plant", Waste Manag., vol. 34, no. 11, pp. 2146-2154, 2014.
[] [PMID: 25151441]
D.H. Qi, and C.F. Lee, "Influence of soybean biodiesel content on basic properties of biodiesel-diesel blends", J. Taiwan Inst. Chem. Eng., vol. 45, no. 2, pp. 504-507, 2014.
E. Christensen, and R.L. McCormick, "Long-term storage stability of biodiesel and biodiesel blends", Fuel Process. Technol., vol. 128, pp. 339-348, 2014.
R. Mahmoudi, A. Emrouznejad, S.N. Shetab-Boushehri, and S.R. Hejazi, "The origins, development and future directions of data envelopment analysis approach in transportation systems", Socioecon. Plann. Sci., 2018.
B. Mohan, W. Yang, and S.k. Chou, "Fuel injection strategies for performance improvement and emissions reduction in compression ignition engines-A review", Renew. Sustain. Energy Rev., vol. 28, pp. 664-676, 2013.
L. Lin, Z. Cunshan, S. Vittayapadung, S. Xiangqian, and D. Mingdong, "Opportunities and challenges for biodiesel fuel", Appl. Energy, vol. 88, no. 4, pp. 1020-1031, 2011.
H.H. Masjuki, and M.A. Kalam, "An overview of biofuel as a renewable energy source: Development and challenges", Procedia Eng., vol. 56, pp. 39-53, 2013.
M.K. Akhtar, H. Dandapani, K. Thiel, and P.R. Jones, "Microbial production of 1-octanol: A naturally excreted biofuel with diesel-like properties", Metab. Eng. Commun., vol. 2, pp. 1-5, 2014.
[] [PMID: 27066394]
A.E. Atabani, A.S. Silitonga, H.C. Ong, T.M.I. Mahlia, H.H. Masjuki, I.A. Badruddin, and H. Fayaz, "Non-edible vegetable oils: A critical evaluation of oil extraction, fatty acid compositions, biodiesel production, characteristics, engine performance and emissions production", Renew. Sustain. Energy Rev., vol. 18, pp. 211-245, 2013.
H.M. Mahmudul, F.Y. Hagos, R. Mamat, A. Abdul Adam, W.F.W. Ishak, and R. Alenezi, "Production, characterization and performance of biodiesel as an alternative fuel in diesel engines – A review", Renew. Sustain. Energy Rev., vol. 72, pp. 497-509, 2017.
M. Habibullah, H.H. Masjuki, M.A. Kalam, I.M. Rizwanul Fattah, A.M. Ashraful, and H.M. Mobarak, "Biodiesel production and performance evaluation of coconut, palm and their combined blend with diesel in a single-cylinder diesel engine", Energy Convers. Manage., vol. 87, pp. 250-257, 2014.
S. Kathirvel, A. Layek, and S. Muthuraman, "Exploration of waste cooking oil methyl esters (WCOME) as fuel in compression ignition engines: A critical review", Eng. Sci. Technol. Int. J., vol. 19, no. 2, pp. 1018-1026, 2016.
M. Özkan, "Comparative Study of the Effect of Biodiesel and Diesel Fuel on a Compression Ignition Engine’s Performance, Emissions, and Its Cycle by Cycle Variations", Energy Fuels, vol. 21, no. 6, pp. 3627-3636, 2007.
"N. keramatsiavash, G. Najafi, R. Hasanbeigi, and B. Ghobadian, “Acoustic Analysis of a Single Cylinder Diesel Engine Using Biodiesel Fuel Blends", Energy Procedia, vol. 75, pp. 893-899, 2015.
B. Ashok, K. Nanthagopal, and D. Sakthi Vignesh, "Calophyllum inophyllum methyl ester biodiesel blend as an alternate fuel for diesel engine applications", Alexandria Eng. J., vol. 57, no. 3, pp. 1239-1247, 2018.
T. Seko, and E. Kuroda, ""Combustion Improvement of a Premixed Charge Compression Ignition Methanol Engine using Flash Boiling Fuel Injection"", Conference: SAE International Fall Fuels & Lubricants Meeting & Exhibition. 2001
L. León-Reina, A. Cabeza, J. Rius, P. Maireles-Torres, A.C. Alba-Rubio, and M.L. Granados, "Structural and surface study of calcium glyceroxide, an active phase for biodiesel production under heterogeneous catalysis", J. Catal., vol. 300, pp. 30-36, 2013.
V.C. Pandey, K. Singh, J.S. Singh, A. Kumar, B. Singh, and R.P. Singh, "Jatropha curcas: A potential biofuel plant for sustainable environmental development", Renew. Sustain. Energy Rev., vol. 16, pp. 2870-2883, 2012.
S. Madiwale, A. Karthikeyan, V. Bhojwani, and M. Dombale, "Improvement of palm oil biodiesel properties using ethanol as an additive and its effect on diesel engine performance, combustion and emissions", J. Eng. Appl. Sci. (Asian Res. Publ. Netw.), vol. 12, pp. 3987-3994, 2017.
A.E. Atabani, A.S. Silitonga, I.A. Badruddin, T.M.I. Mahlia, H.H. Masjuki, and S. Mekhilef, "A comprehensive review on biodiesel as an alternative energy resource and its characteristics", Renew. Sustain. Energy Rev., vol. 16, no. 4, pp. 2070-2093, 2012.
F.D. Gunstone, and I.A. Ismail, "Fatty acids Part 14 The conversion of the cis octadecenoic acids to their trans isomers", Chem. Phys. Lipids, vol. 1, no. 3, pp. 264-269, 1967.
G. Knothe, and R. Dunn, "A Comprehensive Evaluation of the Melting Points of Fatty Acids and Esters Determined by Differential Scanning Calorimetry", J. Am. Oil Chem. Soc., vol. 86, pp. 843-856, 2009.
J.A. Barve, and F. Gunstone, "Fatty acids, Part 33 The synthesis of all the octadecynoic acids and all the trans-octadecenoic acids", Chem. Phys. Lipids, vol. 7, pp. 311-323, 1971.
B. Grau, E. Bernat, P. Rita, R. Jordi-Roger, and R. Antoni, "Environmental life cycle assessment of rapeseed straight vegetable oil as self-supply agricultural biofuel", Renew. Energy, vol. 50, pp. 142-149, 2013.
"T. Liu, W.M. Yang, J. Li, J. Gong, and Y. Deng, “Effects of fatty acid methyl esters proportion on combustion and emission characteristics of a biodiesel fueled diesel engine", Energy Convers. Manage., vol. 117, pp. 410-419, 2016.
Z. Zhang, "J. E, Y. Deng, M. H. Phama, W. Zuo, Q. Peng, and Z. Yin. “Effects of fatty acid methyl esters proportion on combustion and emission characteristics of a biodiesel fueled marine diesel engine", Energy Convers. Manage., vol. 159, pp. 244-253, 2018.
S. Murillo, J.L. Míguez, J. Porteiro, E. Granada, and J.C. Morán, "Performance and exhaust emissions in the use of biodiesel in outboard diesel engines", Fuel, vol. 86, no. 12, pp. 1765-1771, 2007.
"M. Phama, D. Zhao, Y. Deng, D. H. Le, W. Zuo, H. Zhu, T. Liu, Q. Peng, and Z. Zhang, “Effect of different technologies on combustion and emissions of the diesel engine fueled with biodiesel: A review", Renew. Sustain. Energy Rev., vol. 80, pp. 620-647, 2017.
B-F. Lin, J-H. Huang, and D-Y. Huang, "Experimental study of the effects of vegetable oil methyl ester on DI diesel engine performance characteristics and pollutant emissions", Fuel, vol. 88, no. 9, pp. 1779-1785, 2009.
X. Shi, Y. Yu, H. He, S. Shuai, J. Wang, and R. Li, "Emission characteristics using methyl soyate–ethanol–diesel fuel blends on a diesel engine", Fuel, vol. 84, no. 12, pp. 1543-1549, 2005.
C.K. Westbrook, C.V. Naik, O. Herbinet, W.J. Pitz, M. Mehl, S.M. Sarathy, and H.J. Curran, "Detailed chemical kinetic reaction mechanisms for soy and rapeseed biodiesel fuels", Combust. Flame, vol. 158, no. 4, pp. 742-755, 2011.
K. Kara, F. Ouanji, E.M. Lotfi, M.E. Mahi, M. Kacimi, and M. Ziyad, "“Biodiesel production from waste fish oil with high free fatty acid content from Moroccan fish-processing industries”, Egypt", J. Petroleum,, vol. 27, no. 2, pp. 249-255, 2018.
J.K. Kim, C.H. Jeon, H.W. Lee, Y.K. Park, K. Min, I. Hwang, and Y.M. Kim, "Effect of accelerated high temperature on oxidation and polymerization of biodiesel from vegetable oils", Energies, vol. 11, p. 3514, 2018.
E. Buyukkaya, "Effects of biodiesel on a DI diesel engine performance, emission and combustion characteristics", Fuel, vol. 89, no. 10, pp. 3099-3105, 2010.
S. Manigandan, P. Gunasekar, J. Devipriya, and S. Nithya, "Emission and injection characteristics of corn biodiesel blends in diesel engine", Fuel, vol. 235, pp. 723-735, 2019.
S. Nagaraja, K. Soorya Prakash, R. Sudhakaran, and M. Sathish Kumar, ""Investigation on the emission quality, performance and combustion characteristics of the compression ignition engine fueled with environmental friendly corn oil methyl ester - Diesel blends",", Ecotoxicol. Environ. Saf.,, vol. 134, no. Pt 2, pp. 455-461. 2016
[] [PMID: 26849952]
"R. and M. Loganathan, “Combustion characteristics of the direct injection diesel engine fuelled with corn oil methyl ester", Int. J. Ambient Energ., vol. 37, pp. 1-7, 2014.
M.S. Shehata, A.M.A. Attia, and S.M. Abdel Razek, "Corn and soybean biodiesel blends as alternative fuels for diesel engine at different injection pressures", Fuel, vol. 161, pp. 49-58, 2015.
Y.H. Tan, M.O. Abdullah, C. Nolasco-Hipolito, N.S.A. Zauzi, and G.W. Abdullah, "Engine performance and emissions characteristics of a diesel engine fueled with diesel-biodiesel-bioethanol emulsions", Energy Convers. Manage., vol. 132, pp. 54-64, 2017.
A. Ibrahim, "An experimental study on using diethyl ether in a diesel engine operated with diesel-biodiesel fuel blend", Eng. Sci. Technol. Int. J., vol. 21, no. 5, pp. 1024-1033, 2018.
T. Suthisripok, and P. Semsamran, "The impact of biodiesel B100 on a small agricultural diesel engine", Tribol. Int., vol. 128, pp. 397-409, 2018.

Rights & PermissionsPrintExport Cite as

Article Details

Year: 2020
Published on: 25 July, 2020
Page: [108 - 113]
Pages: 6
DOI: 10.2174/2212711906666200224094505
Price: $25

Article Metrics

PDF: 11