PNN and BP Neural Network Fault Diagnosis Research on Electronic Accelerator Pedal Detection

Author(s): Yuxiu Jiang, Xiaohuan Zhao*

Journal Name: Recent Patents on Engineering

Volume 14 , Issue 2 , 2020


Become EABM
Become Reviewer
Call for Editor

Graphical Abstract:


Abstract:

Background: The working state of electronic accelerator pedal directly affects the safety of vehicles and drivers. Effective fault detection and judgment for the working state of the accelerator pedal can prevent accidents.

Methods: Aiming at different working conditions of electronic accelerator pedal, this paper used PNN and BP diagnosis model to detect the state of electronic accelerator pedal according to the principle and characteristics of PNN and BP neural network. The fault diagnosis test experiment of electronic accelerator pedal was carried out to get the data acquisition.

Results: After the patents for electronic accelerator pedals are queried and used, the first measured voltage, the upper limit of first voltage, the first voltage lower limit, the second measured voltage, the upper limit of second voltage and the second voltage lower limit are tested to build up the data samples. Then the PNN and BP fault diagnosis models of electronic accelerator pedal are established. Six fault samples are defined through the design of electronic accelerator pedal fault classifier and the fault diagnosis processes are executed to test.

Conclusion: The fault diagnosis results were analyzed and the comparisons between the PNN and the BP research results show that BP neural network is an effective method for fault detection of electronic throttle pedal, which is obviously superior to PNN neural network based on the experiment data.

Keywords: Electronic accelerator pedal, detection, PNN, BP, fault diagnosis, effective fault detection.

[1]
N. Djordjevic, “Accelerator pedal”,. US006553863B1, 2003.,
[2]
S. Byun, “Electronic accelerator pedal”,. US20160342173A1,2016,
[3]
C. Ho, and C. Spence, "Assessing the effectiveness of various auditory cues in capturing a driver’s visual attention", J. Exp. Psychol. Appl., vol. 11, no. 3, pp. 157-174, 2005.
[http://dx.doi.org/10.1037/1076-898X.11.3.157 ] [PMID: 16221035]
[4]
N. Perera, and A.D. Rajapakse, "Recognition of fault transients using a probabilistic neural-network classifier", IEEE Trans. Power Deliv., vol. 26, no. 1, pp. 410-419, 2010.
[http://dx.doi.org/10.1109/TPWRD.2010.2060214]
[5]
G.Q. Liu, S.H. Yin, and X.T. Wang, "Improved fault diagnosis method based on probabilistic neural network", Adv. Mat. Res., vol. 433, pp. 6084-6088, 2012.
[http://dx.doi.org/10.4028/www.scientific.net/AMR.433-440.6084]
[6]
L. Marinai, D. Probert, and R. Singh, "Prospects for aero gas-turbine diagnostics: a review", Appl. Energy, vol. 79, no. 1, pp. 109-126, 2004.
[http://dx.doi.org/10.1016/j.apenergy.2003.10.005]
[7]
G.L. Zuo, S.D. Lai, and Y. Cheng, "Study on the fault diagnosis of gear pump based on PNN neural network", Adv. Mat. Res., vol. 1044, pp. 873-876, 2014.
[http://dx.doi.org/10.4028/www.scientific.net/AMR.1044-1045.873]
[8]
X.X. Ji Z.M.Wang , "Faults diagnosis of ball bearing based on probabilistic neural network", Appl. Mech. Mater., vol. 543, pp. 1149-1152, 2014.
[http://dx.doi.org/10.4028/www.scientific.net/AMM.543-547.1149]
[9]
X.X. Wang, "A hybrid KPCA-PNN approach to condenser fault diagnosis with a particle swarm optimizer", Adv. Mat. Res., vol. 108, pp. 476-481, 2010.
[http://dx.doi.org/10.4028/www.scientific.net/AMR.108-111.476]
[10]
F. Aminian, and M. Aminian, "Fault diagnosis of nonlinear analog circuits using neural networks with wavelet and fourier transforms as preprocessors", J. Electron. Test., vol. 17, no. 6, pp. 471-481, 2001.
[http://dx.doi.org/10.1023/A:1012864504306]
[11]
X. Jiao, B. Jing, and Y. Huang, "Research on fault diagnosis of airborne fuel pump based on EMD and probabilistic neural networks", Microelectron. Reliab., vol. 75, no. 75, pp. 296-308, 2017.
[http://dx.doi.org/10.1016/j.microrel.2017.03.007]
[12]
J. Zhong, P.K. Wong, and Z. Yang, "Fault diagnosis of rotating machinery based on multiple probabilistic classifiers", Mech. Syst. Signal Process., vol. 108, pp. 99-114, 2018.
[http://dx.doi.org/10.1016/j.ymssp.2018.02.009]
[13]
D. Ma, Y. Liang, and X. Zhao, "Multi-BP expert system for fault diagnosis of power system", Eng. Appl. Artif. Intell., vol. 26, no. 3, pp. 937-944, 2013.
[http://dx.doi.org/10.1016/j.engappai.2012.03.017]
[14]
W.Q. Xiang, Z. Hua, and H. Wang, "Application of BP neural network with L-M algorithm in power transformer fault diagnosis", Power Syst. Protec. Control, vol. 88, no. 8, pp. 170-174, 2011.
[15]
W. Cong, B. Jing, H.K. Yu, and B.P. Adaptive, "Wavelet neural network method for soft fault diagnosis in analog circuit", Adv. Mat. Res., vol. 307, pp. 327-330, 2013.
[http://dx.doi.org/10.4028/www.scientific.net/AMM.307.327]
[16]
L.X. Lu, Y. Zhao, and G.Q. Li, "Fault diagnosis of bearing based on conjugate gradient BP algorithm", Adv. Mat. Res., vol. 1039, pp. 191-196, 2014.
[http://dx.doi.org/10.4028/www.scientific.net/AMR.1039.191]
[17]
L.E. Eijsink, S.C. Perdriau, J.G. de Vries, and E. Otten, "Metal-ligand cooperative activation of nitriles by a ruthenium complex with a de-aromatized PNN pincer ligand", Dalton Trans., vol. 45, no. 40, pp. 16033-16039, 2016.
[http://dx.doi.org/10.1039/C6DT02478E ] [PMID: 27727356]
[18]
G.M. Foody, "Thematic mapping from remotely sensed data with neural networks: MLP, RBF and PNN based approaches", J. Geogr. Syst., vol. 3, no. 3, pp. 217-232, 2001.
[http://dx.doi.org/10.1007/PL00011477]
[19]
Z. Tang, S. Mandal, and N.D. Paul, "Rhodium catalysed conversion of carbenes into ketenes and ketene imines using PNN pincer complexes", Org. Chem. Front.. vol. 2, no. 12, pp. 1561-1577,2015,
[http://dx.doi.org//10.1039/C5QO00287G]
[20]
K. Hermann, B. Joachim, and G. Ulrich, “Supervisory system for a vehicle accelerator pedal travel transducer”,. US005150681A, 1992.,
[21]
M. Tripathy, R.P. Maheshwari, and H.K. Verma, "Probablistic neural network based protection of power transformer", IET Electr. Power Appl., vol. 1, pp. 793-798, 2007.
[http://dx.doi.org/10.1049/iet-epa:20070009]
[22]
J.H. Joo, G.P. Correia, J.L. Li, M.C. Lopez, H.V. Baker, and S.P. Sugrue, "Transcriptomic analysis of PNN- and ESRP1-regulated alternative pre-mRNA splicing in human corneal epithelial cells", Invest. Ophthalmol. Vis. Sci., vol. 54, no. 1, pp. 697-707, 2013.
[http://dx.doi.org/10.1167/iovs.12-10695 ] [PMID: 23299472]
[23]
S. Souahlia, K. Bacha, and A. Chaari, "MLP neural network-based decision for power transformers fault diagnosis using an improved combination of Rogers and Doernenburg ratios DGA", Int. J. Electr. Power Energy Syst., vol. 43, no. 1, pp. 1346-1353, 2012.
[http://dx.doi.org/10.1016/j.ijepes.2012.05.067]
[24]
S. Daliento, A. Chouder, and P. Guerriero, "Monitoring, diagnosis, and power forecasting for photovoltaic fields: a review", Int. J. Photoenergy, vol. 2017, pp. 1-13, 2017.
[http://dx.doi.org/10.1155/2017/1356851]
[25]
B.H.M. Sadeghi, "A BP-neural network predictor model for plastic injection molding process", J. Mat. Pro. Tech., vol. 103, no. 3, pp. 411-416, 2000.
[http://dx.doi.org/10.1016/S0924-0136(00)00498-2 ]
[26]
N. Gokmen, E. Karatepe, and S. Silvestre, "An efficient fault diagnosis method for PV systems based on operating voltage-window", Energy Convers. Manage., vol. 73, no. 5, pp. 350-360, 2013.
[http://dx.doi.org/10.1016/j.enconman.2013.05.015]
[27]
C.E. Lin, J.M. Ling, and C.L. Huang, "An expert system for transformer fault diagnosis using dissolved gas analysis", IEEE Trans. Power Deliv., vol. 8, pp. 231-238, 1993.
[http://dx.doi.org/10.1109/61.180341]
[28]
M. Demetgul, I.N. Tansel, and S. Taskin, "Fault diagnosis of pneumatic systems with artificial neural network algorithms", Expert Syst. Appl., vol. 36, no. 7, pp. 10512-10519, 2009.
[http://dx.doi.org/10.1016/j.eswa.2009.01.028]
[29]
N.B. Zhao, S.Y. Li, and S. Yi, "Fault diagnosis based on rough set and BP neural network (RS-BP) for gas turbine engine", Adv. Mat. Res.,. vol. 732, pp. 397-401, 2013.,
[http://dx.doi.org/10.4028/www.scientific.net/AMR.732-733.397]
[30]
X.F. Liu, and M.F. Peng, "Grounding grids fault diagnosis based on PCA-BP neural network", Adv. Mat. Res., vol. 516, pp. 1774-1778, 2012.
[http://dx.doi.org/10.1002/adma.201290080]
[31]
V. Ravi, H. Kurniawan, and P.N. Thai, "Soft computing system for bank performance prediction", Appl. Soft Comput., vol. 8, no. 1, pp. 305-315, 2008.
[http://dx.doi.org/10.1016/j.asoc.2007.02.001]
[32]
Y. Cheng, C. Yin, and L. Bai, "Fault diagnostics of rolling bearings using feature fusion based BP, RBF and PNN neural networks", Int. J. Appl. Electromagn. Mech., vol. 24, pp. 95-102, 2016.
[http://dx.doi.org/10.3233/JAE-162080]
[33]
X. Sun, F. Kang, and M. Wang, "Improved probabilistic neural network PNN and its application to defect recognition in rock bolts", Int. J. Mach. Learn. Cybern., vol. 7, no. 5, pp. 909-919, 2016.
[http://dx.doi.org/10.1007/s13042-016-0506-2]
[34]
Q. Liang, H. Han, and X. Cui, "Comparative study of probabilistic neural network and back propagation network for fault diagnosis of refrigeration systems", Sci. Tech. Built Environ., vol. 24, no. 4, pp. 448-457, 2018.
[http://dx.doi.org/10.1080/23744731.2017.1375012]
[35]
J.S. Mckenzie, J.M. Jurado, and F. Pablos, "Characterisation of tea leaves according to their total mineral content by means of probabilistic neural networks", Food Chem., vol. 123, no. 3, pp. 859-864, 2010.
[http://dx.doi.org/10.1016/j.foodchem.2010.05.007]
[36]
X. Jiao, B. Jing, and Y. Huang, "Research on fault diagnosis of airborne fuel pump based on EMD and probabilistic neural networks", Micro Relia, vol. 75, no. 75, pp. 296-308, 2017.
[http://dx.doi.org/10.1016/j.microrel.2017.03.007]
[37]
H. Fourn, and H. Ait Atmane, "A novel four variable refined plate theory for wave propagation in functionally graded material plates", Steel Compos. Struct., vol. 27, pp. 109-122, 2018.
[38]
M. Bourada, and A. Tounsi, "A novel refined plate theory for stability analysis of hybrid and symmetric S-FGM plates", Struct. Eng. Mech., vol. 68, pp. 661-675, 2018.
[39]
B. Karami, and M. Janghorban, "A size-dependent quasi-3D model for wave dispersion analysis of FG nanoplates", Steel Compos. Struct., vol. 28, pp. 99-110, 2018.
[40]
A. Younsi, and A. Tounsi, "Novel quasi-3D and 2D shear deformation theories for bending and free vibration analysis of FGM plates", Geomech. Eng., vol. 14, pp. 519-532, 2018.
[41]
F. Bourada, and A.A. Bousahla, "Dynamic investigation of porous functionally graded beam using a sinusoidal shear deformation theory", Wind Struct., vol. 28, pp. 19-30, 2019.
[42]
X.E.J. Zhao, "A review of studies using graphenes in energy conversion, energy storage and heat transfer development", Energy Convers. Manage., vol. 184, pp. 581-599, 2019.
[http://dx.doi.org/10.1016/j.enconman.2019.01.092]
[43]
Y. Deng, and H. Liu, “Effects of cold start control strategy on cold start performance of the diesel engine based on a comprehensive preheat diesel engine model”,.Appl. Energy, vol. 210, pp. 279-287, 2018.,
[http://dx.doi.org/10.1016/j.apenergy.2017.10.093]
[44]
I. Hiroshi, H. Masami, and W Koji, “Fault diagnosis method, fault diagnosis system, and fault diagnosis device for engine”,. US009151238B2, 2015.,
[45]
J. Christoph, M. Joerg, and G. Wolfgang, “Method for detecting faults in an electronically controlled drive system of a motor vehicle”,. US008725348B2, 2014,


open access plus

Rights & PermissionsPrintExport Cite as

Article Details

VOLUME: 14
ISSUE: 2
Year: 2020
Published on: 28 October, 2020
Page: [205 - 220]
Pages: 16
DOI: 10.2174/1872212113666190911124334

Article Metrics

PDF: 22
HTML: 1